立窑

对河南济源五星集团水泥厂立窑熟料进行岩相检验和XRD分析。

The XRD and petrographic analysis on the shaft kiln clinker from the cement plant under Jiyuan wuxing group , were taken in this paper .

立窑烧高KH熟料的工艺措施

Technologic measures taken for producing high KH value clinker in shaft kiln

FUZZY控制理论在水泥机立窑煅烧过程的应用

The application of fuzzy control theory for burning process in mechanized shaft cement kiln

ABBIndustrialITDCS在立窑水泥生产中的应用

The Application of ABB Industrial IT DCS in the Vertical Kiln for Cement Production

水泥立窑煅烧STD工业控制计算机分布式控制系统

Distributing control system with STD industry control computer for shaft cement calcining kiln

我国六大通用水泥新标准和ISO强度检验方法的实施，使立窑水泥面临着生存与发展的严峻挑战。

The implementation of the six new common cement standards and ISO strength inspecting method gives severe challenges to the shaft kiln cement .

讨论了单温区烧结和双温区烧结的特点，指出单温区烧结宜于生产高Br高Hc产品；机立窑高温带的形成与稳定应采取措施降低烧结带的温度。

The sintering characteristics of both single and double temperature zone is discussed . It shows that single zone sintering is suitable for producing ferrites with high B r and H c .

对立窑喷窑事故的原因，本文提出的观点与众不同，作者认为并非CO爆炸所致，而是由于压缩空气受热激烈膨胀造成。

Regarding the reasons of kiln burst-out accidents an out-of-ordinary opinion is presented in the article which considers that the accidents are caused by the intensive expansion of heated compressed air but not by any explosion of CO.

介绍了运用定向控制爆破技术拆除35m高框架结构水泥立窑的方案设计和爆破参数确定。

The scheme and blasting parameters of demolishing 35-meter high reinforced concrete kiln using directional blasting is presented .

本文采用自适应变步长的BP算法，提出了水泥立窑煅烧过程的神经网络控制方案，仿真计算结果证明，本方案是切实可行的。

In this paper , the BP algorithm of adaptive variable step is presented and the scheme of neural network control for the calcining process of cement kiln is abc put forward . The simulation results prove it practicable .

结果表明，回转窑与立窑熟料混合后，其1d水化速率并非两种水泥水化速率的简单加权，而是有明显加快；

The results indicate that the hydration rate of the intermixed clinker at 1d was accelerated instead of being the simple sum of that of the starting clinkers .

采用自制高活性度石灰和传统工业立窑煅烧石灰两种原料来合成纳米碳酸钙，对碳化过程中悬浮体系的pH值和粘度的变化规律及碳酸钙产品的质量进行了比较分析。

The nano calcium carbonate was synthesized by using the lime with high activity and the lime calcining from traditional industrial kiln as primary materials . The change of pH value and viscosity in carbonization process of suspension were compared and analyzed .

QSA水泥立窑计算机集散控制系统

Computer-Distributing Control System of QSA Cement Vertical Kiln

对不同的窑型，窑烟灰中Pb的含量均高于入窑物料中的含量，以立窑尤为明显，且窑烟灰的颗粒越细，其Pb的含量越高。

The kiln dust contains a mass of Pb , its content is much higher than the content of the raw material , and the smaller the kiln dust particle is , the higher the content of Pb is .

COREX技术是利用熔铁煤气化和立窑矿石还原代替传统的焦炉和高炉的一种炼铁新技术，已在南非、韩国和印度得到工业应用。

COREX technology is one of new iron making technologies which use a molten iron gasifier and a reduction shaft instead of coke oven and blast furnace .

SD-3型机立窑湿法高压静电除尘器

SD - 3 Wet Method High Pressure Electrostatic Collector in Vertical Kiln

本课题完成了JLY3809机立窑（加料及窑罩部件）设计。

This subject designs the charging and hooding parts of JLY3809 kiln .

在相同的水化条件下，通过水化程度分析、水化液相分析、XRD、DTA和SEM等方法研究了回转窑与立窑熟料混合配制的水泥的水化特性。

The characteristics of hydration of cement intermixed by the clinkers made in rotary kiln and shaft kiln was studied under the same hydration condition through the analyses of hydration degree , chemical composition of liquid phase , XRD , DTA and SEM etc. .

本文运用烧成范围的概念并结合具体实验讨论了立窑生产中煅烧方案以及复合矿化剂中CaF2的掺量对立窑熟料煅烧性能、质量的影响。

With the concept of sintering range and test results , the influences on the burning per - formances and quality of shaft kiln clinker by sintering plans and CaF_2 addition in compo - und mineralizers are discussed .

介绍了GMC脉喷型袋除尘器的工作原理和技术特点，同时分析了水泥生产过程中烘干设备、立窑、回转窑窑尾和篦冷机等扬尘点的高温烟气特点。

This paper introduces the working principle and technical characteristics of GMC bag filter and analyzes the features of high temperature exhaust gas from several dust generating points such as drying machine , roller mill , preheater and cooler etc.

安徽省东关水泥厂立窑采用晶种煅烧工艺后，原用LFEF装除尘器出罢了结露等一系列不良工况。

After adopting crystal seed burning in shaft kiln , the existing LFEF bag filter appeed a serial of abnormal working condition like dew etc.

使用高硫烟煤外加萤石，形成氟、硫复合矿化作用，加上高KH、高铁配料，掺入混合材，降低水泥中SO3含量，能提高立窑水泥产质量。

Increasing production and improving quality of shaft kiln cement ran be done by using high sulfur bituminous coal adding fluorite to form fluo & sulfur composite mineralization and high KH , high Fe proportion , mixing admixture to reduce SO_3 content in cement .

水泥立窑偏火的模糊控制

Fuzzy Control for the Deflected Burning of Mechanized Shaft Cement Kiln

立窑废气收尘技术探讨

An Approach to Dust-Collecting Technology for Flue Gas from Vertical Kiln

水泥厂机立窑用电除尘器研究

Study of electrostatic precipitator for mechanical shaft kiln in cement works

新型干式除尘器在立窑上的应用

Application of New Type Dry Process Dust Collector in Shaft Kiln

35米高水泥立窑的定向爆破拆除

The Directional Demolishment of 35-meter High Concrete Kiln Using Blasting Technology

立窑水泥生料质量控制装置

The Control Device of Unprocessed Material Quality for Vertical Kiln Cement

利用控制爆破方法拆除立窑

The dismantle of a vertical kiln by the controlled blasting technique

提高立窑水泥质量的技术措施

Measures of improving the quality of cement produced by shaft kiln